Spray Gun Useage Essay, Research Paper
EM 380 Professional Spray Gun
Spray guns may not seem to play an important part in the building construction industry but their speed, efficiency and cost effectiveness all combine to make this power tool integral for builders everywhere.
The spray gun can be used for a wide variety of tasks ranging from painting a small cabinet, to a mid-sized shed, to a large room. Its? basic ?point, trigger, spray? pattern allows virtually anyone to use it, and provides them with faster, more efficient results than if they?d used a brush. This spray gun provides even coats by spraying as good a pattern as allowed by the user. Of course if you have shaky hands, or don?t clean your tips and parts regularly, then you will not get the desired results. By lapping your strokes about 50% over the previous stroke, you can attain uniform paint thickness. When attempting a professional finish it?s best to go right-to-left and then left-to-right (or vise-versa depending on which hand you are using).
Technical data below shows the type of motor, capacity of motor and pump, and the main wetted components
Electric Motor: 0.5 hp, 1725 rpm, 115v, 60 HzAC,
single use phase with automatic reset thermal
overload switch.
Paint Pump: 2500 psi (172 bar) maximum working
pressure; 0.33gpm output.
Components: Delrin, Teflon, Leather, Stainless Steel,
Polyethylene, Tungsten Carbide, Polyurethane, Nylon,
Aluminum, Nitralloy.
To make sure your spray gun is in prime operating condition, you need to make sure to flush your system before and after every use and to follow a few basic guidelines outlined below.
-When first connecting hose and gun, make sure the sprayer is not plugged in and that the tip is not yet installed.
-Make sure the packing nut on the pump is supplied with throat seal liquid.
-Make sure the systems? ON/OFF switch is OFF before plugging it in.
-Keep pressure control knob on the lowest setting.
-Make sure your pump has been flushed, and that there is no left over residue from the cleanser.
-When the paint suction tube is inside the pail of paint, and your drain valve is closed, let off the trigger safety and squeeze into a metal waste container to force out the air.
-Now remove the retaining nut from the gun and install the tip. Re-tighten retaining nut by hand, and then give a one-quarter turn with a wrench.
After you adjust the spray pattern you are ready to begin painting. By following the steps outlined on the previous page and by keeping the gun 12 to 14 inches away at a perpendicular angle to your surface, you should end up with a great finished product. Although the spray gun may not be as convenient as a brush on small projects, it gives an advantage when used on large ones such as rooms. By aiming the gun to the center of a corner to spray you get an evenly sprayed corner. The speed and range make this tool popular for home use around the world.
Remember to practice safety with eye protection and to keep as much skin covered as possible. Have fun suckers
Другие работы по теме:
Romeo An Juliet Essay Research Paper hi
Romeo An Juliet Essay, Research Paper hi i need an essay about a character in romeo and juliet that demonsrtated maturity. in a well developed multi pagraph essay and say why you think the character’s maturity was greater than the other characters in the play.
Turbo Or Nitrous Essay Research Paper Turbo
Turbo Or Nitrous Essay, Research Paper Turbo or Nitrous As you are driving, you see many cars going over the speed limit. Many of the drivers are into racing and modifying their cars. In most cars there are two major modifications that can be done, they are; turbo kit, or a nitrous kit. Both increase horsepower dramatically, but one is instant and the other goes into effect after a certain rpm.
Process Essay Essay Research Paper Process EssayI
Process Essay Essay, Research Paper Process Essay I have found an effective way of getting ready in the morning that saves me time. I am going to share this information with my friend Stephanie. The order in which I get
Cleanig Your Throne Essay Research Paper CLEANING
Cleanig Your Throne Essay, Research Paper CLEANING YOUR THRONE This past summer I worked as a custodian in a manufacturing plant. Part of my job was cleaning bathrooms. I estimate throughout the summer I cleaned up to five
Jane Erye Essay Research Paper Jane Erye
Jane Erye Essay, Research Paper Jane Erye’s Life So far I have been able to compare Jane Erye to life today. The beginning pages describe this part of Jane’s life as cold, dark, and alone. The lines about of winter in Bewick allude to her life at this time, “centuries of winter…of extreme cold…Of these death-white realms I formed an idea of my own: shadowy. ” She is like the rock standing up alone in a sea of billow and spray; the broken boat stranded on a desolate coast; to the cold and gastly moon glancing through the bars of a cloud at a wreck just sinking.” As I first read this I thought of Jane as the moon looking throught the bars, like later when she is locked in the red room.” No jail was ever more secure,” then I thought that the cold and ghastly moon was Mrs.
Chlorofluorocarbons CFCs Essay Research Paper CFCs are
Chlorofluorocarbons (CFCs) Essay, Research Paper CFCs are a family of man-made gases used for various industrial purposes. First developed in the 1920’s in the United States, CFCs have been used in large quantaties since 1950. The industrialized countries can account for over 80% of CFCs use. CFC-11 is used primarily as a propellant in aerosol cans, although its use has been phased out it is still used in the production of plastic foams.
Oh Really Essay Research Paper Oh Reallyyou
Oh Really? Essay, Research Paper Oh Really, you think i am a lark, the dogs they run and bark, but when i say to them, shut up shut up shut up, you say to be nice to them,
A Wonderful Lifemaybe Essay Research Paper A
A Wonderful Life(maybe) Essay, Research Paper A Wonderful Life (maybe) Remember when life was grand? You could go outside, smell the ?fresh? air, walk barefoot without worring about something diseased finding it?s way into your foot.
Shane Essay Research Paper Sometimes I need
Shane Essay, Research Paper Sometimes, I need you more than I need air And sometimes I miss you more than I will forever, never forget the times that we have shaared. The are priceless
Poem Belong Essay Research Paper Where I
Poem: Belong Essay, Research Paper Where I belong I am weak, I am strong I will fit where I belong don’t know where it is for now but it will come, if I allow tomorrow, I start a brand new day
Space Exploration Essay Research Paper If the
Space Exploration Essay, Research Paper If the nation is serious about the manned exploration and development of space, then more attention must be focused now on research to study how weightlessness and reduced gravity would affect everything from power production to plumbing. The research is critical for the development of space-related technologies.
Corporal Punishment Essay Research Paper Corporal Punishment
Corporal Punishment Essay, Research Paper Corporal Punishment People a few years ago,thought of the only way to punish someone who did a sinister deed was to use corporal punishment.This is meant to enforce pain to someone who has done wrong by hitting them,beating them,strapping them or even whipping them.These are only a few examples of corporal punishment.
Him Essay Research Paper I think about
Him Essay, Research Paper I think about him day and night The though won’t go away And, oh, how I would hold him tight every second of the day He is perfect, that is true, not an average me or you
Agent Orange Essay Research Paper Agent Orange
Agent Orange Essay, Research Paper Agent Orange Link Diabetes Strongly Associated With Vietnam Exposure to Pesticide U.S. Air Force planes spray the defoliant chemical Agent Orange over dense vegetation in South Vietnam in this 1966 photo. Dioxin is the component of Agent Orange linked to many health effects in laboratory animals. (AP Photo)
My Room Essay Research Paper The room
My Room Essay, Research Paper The room was small and dark. The air was humid and had a stale, musty smell to it. You would think that the building should have been condemned and abandoned long ago. The door, hanging loosely on two rusty hinges, could barely be opened enough to let a person pass. The floor was littered with junk ranging from filthy socks that stood unsupported, to half a pizza that was far beyond edible.
Poem She Sat Essay Research Paper She
Poem: She Sat Essay, Research Paper She sat… helpless in her room praying to whatever god there may be to let her call to him. could god ignore such a painful cry?
How To Make A Pizza Essay Research
Paper How To Make A Pizza I understand that you are one of our new employees and I am suppose to teach you how we make our pizza. The first thing that you do is take one of our screens from the shelf and a dough ball
Extinction Of Dinos Essay Research Paper Theories
Extinction Of Dinos Essay, Research Paper Theories of the Extinction of the Dinosaurs Controversy surrounds the extinction of the dinosaurs. According to one theory, dinosaurs were slowly driven to extinction by environmental changes linked to the creeping withdrawal of shallow seas from the continents at the end of the dinosaur era.
In HOuse Pollution Essay Research Paper IntroductionThe
In HOuse Pollution Essay, Research Paper Introduction The phrase ?House? isn?t a strange thing for us. Everyone in the earth wish to has his or her own house to live in. People use their house for shelter and a place to sleep, cook, bath, relax and many more. What?s the most important is that they could spend their time with their families.
Ode To Boys Essay Research Paper We
Ode To Boys Essay, Research Paper We like them But do they like us The ones we do never fuss They don’t stop in And we wonder why We stress, we bitch We sometimes cry
Purple Loosestrife Essay Research Paper subject
Purple Loosestrife Essay, Research Paper subject = Biology title = Purple Loosestrife papers = Lvl1 Biology 9/12/96 Purple Loosestrife Lythrum Salicaria L. or Purple Loosestrife is a plant causing much trouble today. It
Oedipa Has No Goal Just As The
Hair Spray Can Has No Aim Essay, Research Paper Oedipa Has No Goal Just As The Hair Spray Can Has No Aim The hair spray can has no aim when it is flying around just as Oedipa
Life Is Like Essay Research Paper Life
Life Is Like Essay, Research Paper Life is like a car. When it?s new, it usually works all right. As time drives by, it breaks down and needs repairs. Life is like a leaf. In its youth, it
Dare Essay Essay Research Paper What DARE
Dare Essay Essay, Research Paper What D.A.R.E Means To Me Dare has prepared me to say no to drugs in eight different ways. If anyone asks me to do drugs I will know what to do, such as- just ignoring the person or just